SUPPLEMENTAL RESTRAINT SYSTEMS  KNEE AIRBAG ASSEMBLY  INSTALLATION  

73900 1.INSTALL LOWER NO. 1 INSTRUMENT PANEL AIRBAG ASSEMBLY

a.

Check that the ignition switch is off.

b.

Check that the cable is disconnected from the negative (-) auxiliary battery terminal.

CAUTION:

Wait at least 60 seconds after disconnecting the cable from the negative (-) auxiliary battery terminal to disable the SRS system.

c.

Connect the airbag connector to the lower No. 1 instrument panel airbag assembly.

NOTICE:

When connecting any airbag connector, take care not to damage the airbag wire harness.

HINT:

Refer to How to Connect or Disconnect Airbag Connector.

Click hereVehicle Interior>SUPPLEMENTAL RESTRAINT SYSTEMS>AIRBAG SYSTEM>HOW TO CONNECT OR DISCONNECT AIRBAG CONNECTOR202111,999999,_58,_111838,_0499714,RM100000001YZEU,

d.

Engage the 2 hooks to temporarily install the lower No. 1 instrument panel airbag assembly.

e.

Engage the claw.

f.

Install the lower No. 1 instrument panel airbag assembly with the 4 bolts.

Torque:

10 N*m (102 kgf*cm, 7 ft.*lbf)

NOTICE:

Confirm that the lower No. 1 instrument panel airbag assembly is installed securely without any excessive gaps and is not protruding outward.

55480D 2.INSTALL LOWER INSTRUMENT PANEL FINISH PANEL ASSEMBLY

58833B 3.INSTALL UPPER NO. 1 CONSOLE PANEL GARNISH

53601 4.CONNECT HOOD LOCK CONTROL LEVER SUB-ASSEMBLY

77306 5.CONNECT FUEL LID LOCK OPEN LEVER SUB-ASSEMBLY (for Gasoline Model)

55545 6.INSTALL FUSE BOX OPENING COVER

55606 7.INSTALL NO. 1 INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY

62112A 8.INSTALL COWL SIDE TRIM SUB-ASSEMBLY LH

67914B 9.INSTALL FRONT DOOR SCUFF PLATE LH

10.CONNECT CABLE TO NEGATIVE AUXILIARY BATTERY TERMINAL

65351A 11.INSTALL BATTERY HOLE COVER (for HV Model)

58416K 12.INSTALL REAR NO. 2 FLOOR BOARD (for HV Model)

13. PERFORM DIAGNOSTIC SYSTEM CHECK

14.INSPECT SRS WARNING LIGHT

15. INITIALIZATION AFTER RECONNECTING AUXILIARY BATTERY TERMINAL